Macronutrient Distribution and Protein Secondary Structure of Cool-Season Oats Revealed by Synchrotron-Based Mid-IR Spectroscopy and FTIR Chemical Imaging: Effects of Variety and Steam-Pressure Toasting Duration
This study aims to investigate changes in protein secondary structures (-helix, -sheet, random coils, and -turn) and macronutrient distribution in different cool-season oat varieties and steam-pressure toasting durations using synchrotron-based mid-infrared (Mid-IR) spectroscopy and Fourier Transform Infrared spectroscopy (FTIR) imaging. All oat samples, provided by the Crop Development Center at the University of Saskatchewan, were harvested over three consecutive years (2018, 2019, and 2020). The first experiment compared four oat varieties (CDC Arborg, CDC Nasser, CDC Haymaker, and Summit), while the second examined CDC Nasser oats subjected to steam-pressure toasting (SPT) at 121 for 0, 30, 60, 90, and 120 minutes. FTIR chemical imaging revealed that carbohydrates, proteins and lipids in the four oat varieties were mainly concentrated in the endosperm, aleurone layer and embryo, crease region, and remained unchanged after SPT. Peak-fitting deconvolution of the Amide I band (1700-1600 cm-1) and subsequent quantitative analysis revealed that the four oat varieties exhibited broadly similar protein secondary structure profiles, with statistically significant but subtle variety effects detected for -helix (P = 0.026), -turn (P = 0.047), and the -helix to -sheet ratio (P = 0.048), however, -sheet and random coil proportions did not differ significantly among varieties. In contrast, SPT induced pronounced structural rearrangements, with significant increase in -sheet proportion (P = 0.003) and significant decreases in random coil content (P = 0.026). Notably, 30 minutes of toasting was sufficient to significantly increase -sheet and decrease the random coil contents. These changes are consistent with heat-induced protein denaturation and intermolecular -sheet aggregation, where thermal energy breaks the hydrogen bonds that stabilize the disordered random coil conformation, causing the unfolded polypeptide chains to reassemble into highly ordered -sheet aggregates. After SPT, the peak centers of Amide I and II bands shifted to lower wavenumbers and both bands broadened while their intensities were maintained, reflecting the reorganization of the remaining protein into -sheet aggregates rather than any loss of amide-active protein. These findings suggest that, although genotype has a relatively minor effect on the protein secondary structure of oats, hydrothermal treatments fundamentally reorganize the protein matrix from a disordered to an ordered conformation, which may have implications for protein digestibility, solubility, and nutritional function.